Chery A15 / 480 LHD model. Instruction - page 39

REMOVAL/INSTALLATION OF SOUND SYSTEM

The sound system includes sound source, speaker and antenna. The sound source includes
recorder assembly, optional CD player assembly and VCD player assembly. The CD player
assembly and VCD player assembly includes the host, power signal line and disks exchanger.

1. INSTALLATION OF THE RECORDER ASSEMBLY

l Disconnect the negative grid of the battery.

l Install the hardware frame into the sub-instrument frame, and using a flat screwdriver to

open the top, bottom, left and right locking plates of the frame;

l Connect the power supply wire, control wires, signal and antenna wires at the back portion
properly;

l Push the playing machine into the mounting frame evenly with your thumbs and

forefingers resting on the left and right of the control panel, till you hear the sound of the
locking plates from both sides of the player.

2. INSTALLATION OF ANTENNA

l Disconnect the negative grid of the battery.

l Install the antenna on the installation hole and align it with the vehicle body;

l Fasten it with washers and non-standard nuts, and connect the conducting wires properly;

l Place the front end of the antenna wiring harness until it reaches the rear of the recorder,

and plug the rear end of the antenna wiring harness into the socket of the antenna;

l Bind the antenna wiring harness along the interior left-hand wiring harness.

3. INATALLATION OF FRONT SPEAKER

l Disconnect the negative grid of the battery.

l Connect the connectors of the wiring harness.

l Place the wiring connection of speaker into installation hole towards the left and fasten it

by turning it towards the right side (note: the connection terminals must face the indoor
after placing the speaker, so as to prevent the panel beating from short circuit. The speaker
should face towards the driver seat);

l Align it at the correct direction and press the speaker cover into it.

4. INSTALLATION OF FRONT DOOR SPEAKER

l Connect the wiring harness properly, and place the speaker plugs upside down into the

speaker mounting position of the door protection guard. After that, mount the speaker
properly;

l Fasten 4 self-tapping screws;

l Align it at the correct direction and press the speaker cover into it.

5. INSTALLATION OF CD EXCHANGER

l Disconnect the negative grid of the battery.

l Install the bracket of the CD exchanger onto the two sides of the exchanger with washers
and screws.

l Fasten the base onto the flat surface of the trunk with the self-tapping screws.

l Ensure the wires between instrument panel and trunk are connected properly.

l Ensure the front of the CD box upwards, and install the CD exchanger vertically on the
base bracket.

The installing steps are reverse to those for removal.

TROUBLESHOOTING

Note: The sound system in the maintenance manual may be different with the actual situation
of the user. We request our staff of the service stations to notify the vehicle owners that there
is a user’s manual for sound system delivered together with all the instruction material of the
vehicle. Thank you!

Malfunction

Reasons/Troubleshooting

No power supply

Connection malfunction. Please check the connection.

The player fails to function
and display.

Check the fuse (player and vehicle) and the connector.

The player functions but
without sound or with poor
sound effect.

Adjust the volume of the player.
Check the sound balancing function.

Check the antenna and its connection.

The player fails to receive the
signal of desired station.

Verify that the antenna is sufficiently spread out and the
connection is proper.
Verify that the negative grid is grounded.
The signal of desired station is too poor.

Displaying “NO DISC” when
searching disc

The disc is incorrectly placed. Insert the disc again correctly.
There is water vapor or dirt on the disc.
Remove the vapor or dirt away from the disc.

Noise, jumping of music

The disc is too dirty. Please clean it.
The disc is twisted or seriously damaged. Compare it with
other discs.
If the disc is defective, please discard it.

Lack of treble sound or lose
tracks when the tape is
playing

Clean the magnetic head.

Tape is loosened.

Check and ensure that the loosened tape has been tightened
properly before inserting it into the recorder again.

The disc ejects when it is
inserted into the player.

The disc has been inserted incorrectly. Insert it correctly
again.

BODY

EXTERIOR ACCESSORIES… … … …… … … …… … … …… … … …… … … S-4

REMOVAL, INSTALLATION & ADJUSTMENT OF ENGINE HOOD… … … …S-4

REMOVAL & INSTALLATION OF HOOD LOCK… … … …… … … …… … …S-5

REMOVAL & INSTALLATION OF FUEL FILLER CAP… … … …… … … …S-6

REMOVAL & INSTALLATION OF EXTERIOR REARVIEW MIRROR… … …S-6

REMOVAL & INSTALLATION OF RADIATOR GRILLE… … … …… … … …S-6

REMOVAL & INSTALLATION OF TRUNK LID TRIM PANEL… … … …… … S-7

REMOVAL & INSTALLATION OF ROOF TRIM MOULDING… … … …S-7

REMOVAL & INSTALLATION OF FRONT WHEEL HOUSE INNER FENDER…S-8

REMOVAL & INSTALLATION OF REAR WHEEL HOUSE INNER FENDER ….S-8

REMOVAL & INSTALLATION OF FRONT BUMPER… … … …… … … …S-8

REMOVAL & INSTALLATION OF REAR BUMPER… … … …… … … …S-10

INTERIOR ACCESSORIES(A11 INTERIOR TRIM)… … … …… … … …… … S-11

REMOVAL & INSTALLATION OF INSTRUMENT PANEL… … … …… … … S-11

REMOVAL & INSTALLATION OF FRONT SEAT BELT… … … …… … … …S-14

REMOVAL & INSTALLATION OF REAR SEAT BELT… … … …… … … …S-15

REMOVAL & INSTALLATION OF FRONT SEAT… … … …… … … …S-16

REMOVAL & INSTALLATON OF REAR SEAT… … … …… … … …… … … S-16

REMOVAL & INSTALLATON OF INNER REARVIEW MIRROR… … … …… S-17

REMOVAL & INSTALLATON OF SUN VISOR & ITS BRACKET… … … …S-17

REMOVAL & INSTALLATON OF PASSENGER GRAB HANDLE… … … …S-17

INTERIOR ACCESSORIES(A15 INTERIOR TRIM)… … … …… … … …S-18

DISASSEMBLY AND ASSEMBLY OF INSTRUMENT PANEL… … … …… … S-18

DISASSEMBLY AND ASSEMBLY OF PACKAGE TRAY TRIM PANEL… … …S-21

DISASSEMBLY AND ASSEMBLY OF REAR SPEAKER… … … …… … … …S-22

DISASSEMBLY AND ASSEMBLY OF SHIFT LEVER… … … …… … … …S-22

DISASSEMBLY AND ASSEMBLY OF GLOVE BOX… … … …… … … …S-22

DISASSEMBLY AND ASSEMBLY OF AIRBAG. … … … …… … … …… … …S-23

Рассказать друзьям